Diggers Titanium General Purpose Cleaner NZ - Recochemhttps://db1736767dbd5e7094bb-d61bbc5d0b342a54145a236e2d5d1ebf.ssl.cf4.rackcdn...
1 downloads
173 Views
275KB Size
SAFETY DATA SHEET SECTION 1
IDENTIFICATION: PRODUCT IDENTIFIER AND CHEMICAL IDENTITY
Product Identifier Other Names Manufacturer’s Product Code Recommended Use
DIGGERS TITANIUM GENERAL PURPOSE CLEANER None 82300 Detergent, cleaner
Details of Supplier/Manufacturer Company: Address: Phone: Website:
Recochem Inc.
ABN: 69 010 485 999
1809 Lytton Road, Lytton, Queensland 4178 (07) 3308 5200
Fax: (07) 3308 5201
www.recochem.com.au
Details of Distributor Company: Address: Phone: Emergency Telephone Numbers Poisons Information: SECTION 2
Owens Logistics 3-5 Kahu Street, Otahuhu, Auckland (09) 270 1310
Fax: (09) 270 1311
0800 764 766
HAZARDS IDENTIFICATION Hazardous chemical Non-dangerous goods Signal Word
Hazardous chemical classification
according to classification by Safe Work Australia according to the Australian Code for the Transport of Dangerous Goods by Road and Rail
WARNING Pictogram
Serious Eye Damage/Irritation, Category 2A
Hazard statement
H319 Causes serious eye irritation EXCLAMATION MARK
Page 1 of 6
ISSUE: 2
ISSUE DATE: 15/06/2016
Product: DIGGERS TITANIUM GENERAL PURPOSE CLEANER Precautionary statements: GENERAL P101 P102 P103 PREVENTATIVE P264 P280 RESPONSE P305 + P351 + P338 P337 + P313 SECTION 3
If medical advice is needed, have product container or label at hand Keep out of reach of children Read label before use Wash thoroughly after handling Wear eye protection/face protection IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing If eye irritation persists: Get medical advice/attention
COMPOSITION AND INFORMATION ON INGREDIENTS
Ingredients Names and Proportions
SECTION 4
Chemical Entity
CAS Number
Proportion (%)
Alkanate CC40
-
4
Water + Dye
-
balance
FIRST AID MEASURES
Description of necessary first aid measures Remove victim from exposure if safe to do so. If rapid recovery does not Inhalation: occur, transport to nearest medical facility for additional treatment. If skin contact occurs, remove contaminated clothing and wash skin Skin Contact: thoroughly with water and follow by washing with soap if available. If in eyes, hold eyes open, flood with water for at least 15 minutes. Seek Eye Contact: immediate medical assistance. If swallowed, do NOT induce vomiting. If vomiting occurs spontaneously, keep Ingestion: head below hips to prevent aspiration. Symptoms caused by exposure Inhalation:
Unlikely to cause irritation.
Skin:
May include redness and itching.
Eye:
May include redness, burning, blurred vision, or swelling.
Ingestion:
Unlikely to cause irritation.
Medical attention and special treatment Treat symptomatically. SECTION 5
FIRE FIGHTING MEASURES
Suitable extinguishing equipment For a small fire use dry chemicals, carbon dioxide, water spray or foam. For large fires use water spray, fog or foam. Do not use water in a jet. Specific hazards arising from the chemical Data not available. Special protective equipment and precautions for fire fighters Wear full protective clothing and self-contained breathing apparatus. Page 2 of 6
ISSUE: 2
ISSUE DATE: 15/06/2016
Product: DIGGERS TITANIUM GENERAL PURPOSE CLEANER SECTION 6
ACCIDENTAL RELEASE MEASURES
Personal precautions, protective equipment and emergency procedures Avoid contact with spilled or released material. Shut off leaks, if possible without personal risks. Isolate hazard area and deny entry to unnecessary or unprotected personnel. Environmental precautions Use appropriate containment to avoid environmental contamination. Prevent from spreading and entering waterway using sand, earth or other appropriate barriers. Attempt to disperse the vapour or to direct its flow to a safe location for example by using fog sprays. Methods and materials for containment and cleaning up For small spills (< 1 drum), transfer by mechanical means to a labelled, sealable container for product recovery or safe disposal. Allow any residues to evaporate or use an appropriate absorbent material and dispose of safely. For larger spills (> 1 drum), transfer by means such as a vacuum truck to a salvage tank for recovery or disposal. Do not flush residues with water. Retain as contaminated waste. Allow any residues to evaporate or use an appropriate absorbent material and dispose of safely. SECTION 7
HANDLING AND STORAGE
Precautions for safe handling Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Do not eat, drink or smoke in contaminated areas. Handle and open containers with care in a well-ventilated area. Conditions for safe storage, including any incompatibilities Store in a cool, well-ventilated area. SECTION 8
EXPOSURE CONTROLS AND PERSONAL PROTECTION
Exposure control measures From National Occupational Health & Safety Commission (NOHSC) Worksafe Australia No exposure standard data available. Biological monitoring No biological limit allocated. Engineering controls Ensure that adequate ventilation is provided. Avoid generating and inhaling mists and vapours. Keep containers closed when not in use. Individual protection measures Eye and face protection: Skin protection:
Respiratory protection:
Thermal hazards:
Page 3 of 6
Wear safety goggles. Use solvent resistant gloves, nitrile for longer term protection or PVC and neoprene for incidental splashes. If work practices do not maintain adequate airborne levels, use appropriate respiratory protection equipment. When using respirators, select an appropriate combination of mask and filter. Select a filter for organic gases and vapours (boiling point > 65°C). Respirators should comply with AS1716 or an equivalent approved by a state/territory authority. Not applicable.
ISSUE: 2
ISSUE DATE: 15/06/2016
Product: DIGGERS TITANIUM GENERAL PURPOSE CLEANER SECTION 9
PHYSICAL AND CHEMICAL PROPERTIES Appearance: Odour: Odour threshold (ppm): pH: Melting point/freezing point (°C):
Initial boiling point and boiling range (°C): Flash point (°C):
Clear yellow liquid None Data not available 7.43 0 approx. 100 approx. > 60
Evaporation rate (Butyl acetate = 1):
Data not available
Flammability:
Data not available
Upper/lower flammability or explosive limits (%):
Data not available
Vapour pressure (mmHg @ 20°C):
Data not available
Vapour density (air = 1):
Data not available
Density (g/ml @ 20°C): Solubility:
Data not available
Partition coefficient: n-octanol/water:
Data not available
Auto-ignition temperature (°C):
Data not available
Decomposition temperature (°C):
Data not available
2
Kinematic viscosity (mm /s @ 20°C): SECTION 10
0.997 approx.
Data not available
STABILITY AND REACTIVITY
Reactivity Stable under normal conditions of use. Chemical stability Stable under normal conditions of use. Possibility of hazardous reactions Stable under normal conditions of use. Conditions to avoid Data not available. Incompatible materials Data not available. Hazardous decomposition products Data not available.
Page 4 of 6
ISSUE: 2
ISSUE DATE: 15/06/2016
Product: DIGGERS TITANIUM GENERAL PURPOSE CLEANER SECTION 11
TOXICOLOGICAL INFORMATION Acute toxicity:
Skin corrosion/irritation: Serious eye damage/irritation: Respiratory or skin sensitisation: Germ cell mutagenicity: Carcinogenicity: Reproductive toxicity: Specific Target Organ Toxicity (STOT) – single exposure: Specific Target Organ Toxicity (STOT) – repeated exposure: Aspiration hazard: SECTION 12
Low toxicity Not expected to be irritating to skin. May be irritating to eyes. Not expected to cause sensitisation Not expected to be mutagenic Not expected to be carcinogenic Not expected to impair fertility Data not available
Data not available Data not available
ECOLOGICAL INFORMATION
Ecotoxicity Acute toxicity: Fish –
No data available
Aquatic invertebrate –
No data available
Algae –
No data available
Microorganisms –
No data available
Chronic toxicity: Fish –
No data available
Aquatic invertebrate –
No data available
Algae –
No data available
Microorganisms –
No data available
Persistence and degradability No data available. Bioaccumulative potential No data available. Mobility in soil No data available. Other adverse effects No data available. SECTION 13
DISPOSAL CONSIDERATIONS
Ensure waste disposal conforms to local waste disposal regulations.
Page 5 of 6
ISSUE: 2
ISSUE DATE: 15/06/2016
Product: DIGGERS TITANIUM GENERAL PURPOSE CLEANER SECTION 14
TRANSPORT INFORMATION UN number:
Not applicable
Proper shipping name:
Not applicable
Australian Dangerous Goods class:
Not applicable
Australian Dangerous Goods packing group:
Not applicable
Hazchem code:
Not applicable
SECTION 15
REGULATORY INFORMATION
Standard for the Uniform Scheduling of Medicines and Poisons (SUSMP), Poisons Schedule: Australian Inventory of Chemical Substances (AICS): Dangerous Goods Initial Emergency Response Guide (SAA/SNZ HB76): New Zealand HSNO, Classification:
SECTION 16
Not scheduled Listed Not applicable 6.4A
OTHER INFORMATION Date of preparation: Revision number: Changes in this revision:
15/06/2016 2 Added P280
This SDS summarises product safety information at the date of issue, to the best of our knowledge, as a general guide. Recochem cannot anticipate or control the conditions under which the product is used, so prior to usage each user must assess and control the risks associated with their use of the product. Users should also consult the relevant legislation governing the use and storage of this product. We make no warranties, express or implied, and assume no liability in connection with any use of information contained within this document. If clarification or further information is needed, the user should contact Recochem on (07) 3308 5200.
Page 6 of 6
ISSUE: 2
ISSUE DATE: 15/06/2016